Home Cured Pork Tenderloin Ham Recipes

Steps:

• Place kosher salt, brown sugar, pickling spice, and pink salt in a container large enough to hold the brine and the ham.
• Bring 2 quarts of water to a boil and pour over the brine ingredients; whisk to dissolve. Pour in 1 gallon fresh cold water to cool down the mixture.
• Score the skin side of the pork roast with a sharp knife. Cut into the fat beneath the skin but not into the meat. Score about 1 inch apart, then score in the opposite direction to get the classic diamond-shaped pattern.
• Lower scored roast into the cooled brine, skin side up. Use a plate to weigh down the roast so that it cures fully submerged in the liquid. Refrigerate for 1 day for every 2 pounds of pork (for a 7 pound roast, cure for at least 2 1/2 days). Turn the roast over halfway through the brining process.
• Remove roast from brining liquid. Discard the brining liquid and transfer the roast back to the brining container. Cover the roast with fresh cold water to rinse off some of the salt. Depending on how salty you want your ham, you can soak it for just a few minutes or overnight. Remove roast from the water and blot dry with paper towels.
• Preheat oven to 325 degrees F. Add a cup of water to a roasting pan with 2 whole star anise. Place roast on a rack in the roasting pan.
• Roast until ham reaches an internal temperature of 130 to 135 degrees F, about 2 hours. Ham will not be fully cooked at this point. If water has nearly evaporated, add a splash more. Increase oven temperature to 425 degrees F. Continue to roast until skin is browned and crispy and ham reaches an internal temperature of 145 to 150 degrees F.
• To make the optional glaze, mix the mustard, maple syrup, cayenne pepper, and salt together in a bowl. Brush glaze on the ham at this point, not before. Return roast to oven for about 5 minutes to crisp it even further.

Steps:

• Put salt and sugar in a large nonreactive bowl (stainless steel or glass). Add boiling water and stir well to dissolve salt and sugar. Add peppercorns, mustard seeds, allspice berries, cloves, thyme and bay leaves. Allow to cool completely.
• Add curing salt and 1 cup white wine to cooled brine. Submerge pork tenderloins in brine. Place plate directly on top of pork to keep it submerged if necessary. Cover container and refrigerate for 5 days.
• Remove pork from brine and pat dry. Discard brine. Spread onions and thyme sprigs on bottom of a large shallow baking dish. Add brined tenderloins in one layer, then add 1/2 cup wine. Heat oven to 350 degrees; as it heats, bring meat to room temperature. Cover dish and bake for 45 minutes or until pork registers 135 degrees with an instant-read thermometer. Remove from oven (meat will continue to cook and reach 140 degrees as it rests). Let cool before cutting into thin slices. Serve with buttermilk biscuits. May be refrigerated, well wrapped, for up to 1 week.

Steps:

• Make the brine: Bring 1 quart of water to a boil in a large saucepan over high heat. Add the sugar, salt and Prague powder. Whisk until dissolved and remove from heat. Stir in 1 quart cold water. Pin the bay leaves to the orange zest strips using the cloves, and add them to the brine. Let the mixture cool to room temperature, about 1 1/2 hours.
• Wash the pork loin and blot dry. Place it in a baking dish just large enough to hold it.
• Measure out 1/2 cup brine into a measuring cup. Draw the brine into a marinade injector and inject it into the center of the pork loin all over, inserting the needle at 1-inch intervals and drawing it out slowly as you depress the plunger, until you've used the full 1/2 cup brine and the brine starts to squirt out of the pork.
• Transfer the pork to a large, heavy-duty resealable plastic bag. Add the brine from the baking dish, plus the remaining brine and seasonings, and tightly seal, squeezing out any air. Return the bagged pork to the baking dish to corral any leaks. Brine the pork in the refrigerator for 24 hours, turning several times along the way so it brines evenly.
• Remove the loin from the brine and place it in another baking dish, reserving the brine. Re-inject the pork loin with the brine in the bag, again using about 1/2 cup (or more if you can get more in), then return the pork to the brine bag and continue brining and turning for another 24 hours, for a total brining time of 48 hours. The meat should turn a shade pinker. At this point, you can dry and smoke the pork loin, but if you brine it for another 24 hours, the flavor will be even richer.
• Drain the brined pork loin in a colander, discarding the brine. Rinse the loin well with cold water, drain again and blot dry with paper towels. Place it on a wire rack over a baking dish and let it dry for 1 hour in the refrigerator.
• Meanwhile, set up your grill for indirect grilling and heat to medium (about 350 degrees). If using wood chips, soak about 3 cups chips in water to cover for 30 minutes, then drain. If using wood chunks, there is no need to soak them.
• Place the pork loin on the grate, fat-side up, over indirect heat, set over a drip pan. Add 1 1/2 cups wood chips or 2 wood chunks to the coals.
• Smoke the pork loin until handsomely browned and cooked through (the internal temperature will be about 155 degrees), about 1 1/2 hours. Add wood chips (about 1 1/2 cups) or chunks (1 large or 2 medium) per hour to the embers to maintain a constant flow of smoke.
• While the pork cooks, make the glaze: Place the orange juice, Cognac, brown sugar, marmalade, cinnamon and cloves in a nonreactive saucepan. Boil over high heat until syrupy and reduced by half, 10 to 15 minutes.
• In a small bowl, whisk together the cornstarch and Cointreau, then carefully whisk the slurry into the glaze. Boil for 1 minute. The glaze will thicken. Whisk in the butter, and season with salt and pepper to taste. (Makes about 1 1/4 cups.)
• Brush the glaze on the pork three times during the last 20 minutes of cooking. Reserve the remaining glaze.
• When the pork is done, transfer to a platter and let rest for 5 minutes. To serve, thinly slice the pork loin across the grain and serve with the remaining glaze on the side.