Molasses Cured Pork Shoulder Bacon Recipes

Steps:

• Put pork butt, fat side up, on a work surface, then halve horizontally with a sharp large knife.
• Stir together water, salt, brown sugar, and Instacure in storage tub until solids are dissolved, about 3 minutes, then add molasses and stir until dissolved. Add ice and stir until cure is cold (ice may not be completely melted; keeping liquid cold slows salt absorption).
• Add pork to cure, then weight with a large plate to keep submerged. Chill, tub covered with a lid or plastic wrap, 36 hours.
• Rinse pork and pat dry, then discard brine. Sprinkle pork evenly with pepper (if using).
• Prepare grill and smoke bacon: See preceding recipe.
• Cut bacon crosswise into 1/8-inch-thick slices with a sharp knife, then fry in a heavy skillet over moderately low heat, turning, until browned. Transfer to paper towels to drain.
• Available at The Sausage Maker (888-490-8525).

Steps:

• Pork:
• Purée garlic, ginger, hoisin sauce, fish sauce, honey, wine, chili oil, oyster sauce, and sesame oil in a blender until very smooth. Place 1 1/2 cups in a small bowl for glaze; cover and chill until ready to use. Pour remaining marinade into a 2-gal. resealable plastic bag.
• Place pork shoulder, fat side down, on a cutting board with a short end facing you. Holding a long sharp knife about 1"-1 1/2" above cutting board, make a shallow cut along the entire length of a long side of shoulder. Continue cutting deeper into meat, lifting and unfurling with your free hand, until it lies flat (it's better to end up with 2-3 even pieces than 1 uneven piece). Add to bag with marinade and seal, pressing out air. Work pork around inside bag to coat with marinade. Chill at least 8 hours and up to 1 day.
• Prepare a Big Green Egg for medium heat (with cover closed, thermometer should register 350°F). Remove pork from marinade, letting excess drip off. Lightly season all over with salt. Fit grill with convection plate and set pork on top. (If you don't have a convection plate, bank coals on one side and set pork over cooler area to avoid flare-ups.) Cover and roast pork until an instant-read thermometer inserted into the thickest part registers 140°F-145°F. (You can also do initial cooking in a 350°F oven.) Transfer to a cutting board and let rest at least 20 minutes.
• Glaze and assembly:
• Bring brown sugar, molasses, and reserved marinade to a simmer in a large saucepan; cook until reduced by one-third, 6-8 minutes (you should have about 1 1/3 cups). Keep warm.
• Prepare a Big Green Egg for medium-high heat (or use a conventional grill). Grill pork, basting and turning with 2 pairs of tongs every minute or so, until thickly coated with glaze, lightly charred in spots, and warmed through (an instant-read thermometer inserted into the thickest part should register 130°F-145°F; be careful not to overcook), 6-8 minutes. Transfer to a cutting board; slice against the grain ¼" thick. Serve with pickles, bread, cilantro, and onion.
• Do Ahead
• Pork can be roasted 2 days ahead. Let cool; cover and chill.

Steps:

• MIX ALL DRY INGREDIENTS TOGETHER IN A BOWL, MIX START TO ADD IN MOLASSES MIXTURE TILL YO HAVE A THIN SLURRY MIXTURE, APPLY MIXTURE TO PORK BELLY RUBBING IT IN COATING THE BELLY EVENLY. PLACE INTO 2 GALLON SEALABLE BAG, REMOVING AS MUCH AIR AS POSSIBLE FOLDING EXCESSIVE BAG UNDER THE BELLY. PLACE IN FRIDGE, FOR 6 - 7 DAYS TILL FIRM TO THE TOUCH, TURNING OVER ONCE A DAY. WHEN READY REMOVE FROM FRIDGE, REMOVE FROM BAG RINSE THOROUGHLY RUBBING IT WITH HANDS AS YOU RINSE TO REMOVE EXCESSIVE SALT. SET ON RACK TO AIR DRY, IF POSSIBLE IN FRIDGE ON THE RACK AND COOKIE SHEET LET DRY 2 TO 3 HOURS PULL FROM FRIDGE AND LET COME UP TO ROOM TEMPERATURE. START YOUR SMOKER. SMOKER TEMP AT 175 F, SMOKE WITH MAPLE OR APPLY FOR 2 HOURS. CONTINUE TO COOK IN THE SMOKER TILL THE BACON HAS REACHED AN I.T. OF 140- 145 THEN REMOVE, PLACE ON COOLING TRAY AND LET COOL, THEN INTO FRIDGE OVER NIGHT TO FIRM UP, NEXT MORNING REMOVE FROM FRIDGE, SLICE, COOK AND ENJOY