Smoked Bologna Or Summer Sausage Recipes

Steps:

• Smash celery into juicy bits using a mortar and pestle. Combine with ground beef in a large bowl. Add garlic powder, paprika, mustard seeds, kosher salt, black pepper, cayenne pepper, curing salt, and sugar. Mix by hand until thoroughly combined.
• Transfer meat onto a large piece of parchment paper. Use damp hands to shape into a 3- to 4-inch-thick log. Roll up in the parchment paper, compressing it as much as possible. Twist ends tightly to seal. Place on a paper towel-lined baking sheet and refrigerate for 24 hours.
• Preheat the oven to 275 degrees F (135 degrees C).
• Cut ends off the parchment paper and unwrap meat. Mix liquid smoke with water and generously brush over the meat. Roll meat back up in the paper, then again in aluminum foil, sealing it tightly and twisting the ends in opposite directions.
• Line a baking sheet with a wire rack and place the sealed meat on top. Poke 5 or 6 holes across the bottom for excess moisture to drip out.
• Bake in the preheated oven until the internal temperature reaches 150 degrees F (66 degrees C) and no higher, about 1 1/2 hours.
• Let sausage cool in the pan until room temperature, at least 30 minutes. Give ends a tighter twist, then refrigerate at least 8 hours, or overnight.
• Unwrap sausage and slice in half. Coat outsides with freshly ground black pepper, place on a plate lined with crinkled foil, and let dry in the refrigerator for 24 hours.

Steps:

• We use mostly mesquite, but I know this would be delicious with hickory.
• Whether I buy a 5lb chub of bologna or 2 lb roll of summer sausage I always cut it in half longways. I think this allow the smoke to evenly penetrate the meat.
• Time will vary depending on what temp you are smoking with. We smoked the bologna for about 2 hrs at 225°. The summer sausage takes about 1 hr. at the heat.
• I always cube the summer sausage and serve as a snack or appetizer, it's great with smoked cheese.
• The bologna I sliced and browned on my griddle before serving as a side for breakfast at supper.

Steps:

• 1. Combine ground meat with all remaining ingredients(except casings)in a large mixing bowl,mix/knead thoroughly up to 2 minutes. (to prepare fibrous casings soak 15 min. in warm water prior to using.
• 2. Taste test by frying a small amount(a size of a quarter or so) a patty to see if you approve the flavor. Make changes if needed.
• 3. Stuff seasoned meat mixture into casings of your choice; refrigerate overnight to cure.
• 4. SMOKER PROCESSING After sausage product has been seasoned,stuffed & cured overnight, hang the sausage product in smoker, carefully positioning so that it's not touching one another. 2. If you have a digital thermometer timer, push the probe into the center of one of the sausages, set the temperature alarm at 152 degrees F. 3. Begin the first hour by setting the temp. to 130-140 degrees; open the smoker damper wide open until the product is dry (tacky) to the touch 4.At beginning of second hr. close damper & adjust smoker temp. to 150-260 degrees & apply smoke for 1hr.and 20 min.Longer is optional if you prefer a heavy smoke. 5.At beginning of the 3rd hr. adjust smoker heat to 170 degrees. Maintain until internal temperature of the sausage product reaches 152 degrees internally at which time the sausage is fully cooked
• 5. Cooling Down the product: Remove sausages from smoker & shower with cool water to stop the cooking process, shower(spray) product until the internal temp of product drops to 120 degreesF.
• 6. Product is ready to eat. Remainder should be packaged & frozen until needed. Venison lovers can grind 9lbs. of trimmed venison and 1lb. beef fat for 10 lbs. of sausage sticks or summer/salami type sausages..enjoy