Cannoli Shells Recipes

Steps:

• Mix together flour, shortening, salt and sugar.
• Add enough wine to make a stiff but workable dough.
• Roll dough into a ball and let it stand for about 1 hour.
• Roll dough out 1/8 inch thick.
• Cut rolled dough into 5x5 inch squares.
• Place a cannoli tube across dough square on an angle (from top left corner to bottom right corner).
• Wrap one corner around the tube, then the other (which should overlap the first).
• Press together to seal seam.
• Fry in deep fat, one at a time, until deep golden brown.
• Carefully remove fried cannoli shell from tube.
• Cool completely before filling.
• ***Cannoli tubes are usually made from sheet aluminum and should be 8 inches long by 1 inch in diameter.

Steps:

• Sift together flour, sugar, cinnamon, and salt. Cut shortening in with a pastry blender until the pieces are the size of small peas. Stir in eggs. Blend in the vinegar and cold water. Turn dough onto a lightly floured surface and knead until smooth and elastic, about 5 minutes.
• Add additional flour, if needed, to get a smooth dough. Wrap in plastic wrap and refrigerate 30 minutes. Set out 6 aluminum cannoli tubes. Heat oil in a deep saucepan to 360 degrees F.
• Cut an oval shaped pattern from cardboard about 6x4-inches. Roll chilled dough on a lightly floured surface to 1/8-inch thickness. Place the cardboard pattern on dough and cut out as many as will fit on the dough. Wrap dough loosely around tubes slightly overlapping opposite ends. Seal ends by brushing with egg white and pressing together.
• Fry only as many shells as will float uncrowded in the hot oil. Fry until light golden brown, 3-4 minutes. Remove cannoli shells to paper towels to drain. Cool slightly and remove the tubes. Cool shells completely. Continue forming and frying cannoli shells.
• Using a pastry bag or a small spoon, fill the shells with the filling from both ends. Do not fill the shells until up to an hour before serving, as the filling will make the shells soggy.
• Sprinkle ends with reserved chopped pistachio nuts and dust with confectioners sugar.

Steps:

• In a medium bowl, stir together the flour, sugar and cinnamon. Using a fork, blend in the white wine. When dough forms a ball, turn out onto a lightly floured surface and knead until smooth, about 15 minutes. Cover and refrigerate for about 2 hours.
• Heat 1 inch of oil in a deep heavy skillet to 365 degrees F (180 degrees F). On a lightly floured surface, roll 1/3 of the dough out into a big circle as thin as paper. Cut into 8 (5-inch) circles. Wrap each circle around a cannoli form, and seal with egg yolk.
• Fry 2 or 3 at a time until golden brown. remove with tongs to drain on paper towels. Carefully remove shells from forms while they are still hot, or they may become stuck.

Steps:

• For the shell dough: In a medium bowl, sift together the flour, sugar and salt. Work the butter pieces into the flour with your fingers until the mixture becomes coarse and sandy. Add the egg yolk and the white wine and mix until it becomes a smooth dough. Spread a piece of plastic wrap on a flat surface and place the dough in the center. Wrap the plastic loosely around it and press the dough to fill the gap. Flattening the dough will mean less rolling later. Let it rest in the fridge for a few minutes while you make the filling.
• For the filling: In a medium bowl, whisk the ricotta until smooth. Sift in the powdered sugar, cinnamon and allspice. Mix to blend. In a separate bowl (or in the bowl of an electric mixer fitted with the whisk attachment), beat the heavy cream until fairly stiff. Using a rubber spatula, gently fold the cream into the ricotta mixture. Stir in the chocolate chips. Lightly zest the exterior of the lemon and stir it into the ricotta. Refrigerate for a half hour to an hour.
• To roll and fry the shells: In a medium pot with a heavy bottom, heat the canola oil to 360 degrees F. Meanwhile, sift an even layer of flour on a flat surface. Flour a rolling pin. Roll the dough until it is very thin (about 1/8-inch thick). Cut the dough into fourths and work in small batches. Use any glass or small bowl that has a 3-to-4-inch diameter. Cut rounds, tracing around each one to assure the dough has been fully cut. You should have about 24 circles. Wrap each circle around a cannoli mold. Use a little of the egg wash on the edge of each round to seal it shut and to assure it won't slide or fall off the mold before pressing it closed over the mold. Flare the edges out slightly from the mold. Flaring will allow the oil to penetrate each cannoli shell as they fry. Use a pair of tongs to hold the edge of the mold as you submerge and fry the shell in the oil until crispy, 2 to 3 minutes. Remove from the oil, and holding the mold in one had with your tongs, gently grip the shell in your other hand with a kitchen towel and carefully slide it off the mold. Set aside to cool. Repeat with all of the circles.
• To fill the cannolis: Just before serving, use a pastry bag without a tip to pipe the ricotta into the cannoli molds. Fill the cannoli shells from both ends so the cream runs through the whole shell. Dust with powdered sugar. Powdered sugar gives that little extra sweetness and added texture to the exterior. It also makes me feel like I have a professional bakery touch in my own home. Serve immediately.

Steps:

• For the cannoli shells: Pulse the flour, granulated sugar, cinnamon and salt together in a food processor. Add the butter and pulse until thoroughly combined. Add the egg yolk and Marsala and process until the dough forms a ball. Turn the dough out onto a piece of plastic wrap and flatten into a disk. Refrigerate for 10 minutes.
• Fill a large, wide pot with 2 inches of oil and heat over medium-high heat to 350 degrees F.
• Meanwhile, lightly flour a work surface and roll the dough out into a thin circle, about 1/8-inch thick. Cut out as many circles as possible with a 3 1/2- to 4-inch round cookie cutter, then gather the scraps, reroll, and cut out more (discard any remaining scraps).
• Line a baking sheet with paper towels. Wrap a circle of dough around a cannoli tube. Lightly moisten an edge with water and press the edges together very firmly to seal (if not well-sealed, the cannoli shells will open while frying). Repeat with as many cannoli tubes as you have. Fry the tubes with the dough, turning once, until the shells are golden brown all over, 4 to 5 minutes. Carefully remove the tubes from the oil and slip off the cannoli shells onto the paper towels. Let the tubes cool slightly, then repeat until all of the dough is fried, adjusting the heat as necessary to keep the oil at 350 degrees F. Cool the shells completely.
• For the filling: Mix the ricotta, confectioners' sugar, orange zest and vanilla together in a bowl until smooth. Stir in the chocolate.
• Fill a pastry bag fitted with a 1/4-inch tip with the ricotta mixture. Hold a cannoli shell in one hand; with the other, insert the pastry tip into the center of the shell and pipe out the filling. Turn the shell around and fill the other side. Repeat with the remaining shells and filling. Arrange on a platter and dust with confectioners' sugar. Serve filled shells immediately; alternatively, store unfilled shells in an airtight container at room temperature for up to 4 days and fill when ready to serve.

Steps:

• To make shells, mix flour, sugar and salt in a bowl.
• Cut in butter.
• Add egg yolks; stir with a fork.
• Stir in wine, 1 tablespooon at a time, with a fork until dough clings together.
• Form a ball with the dough and let stand for 30 minutes.
• Roll dough almost paper thin, on a well-floured surface.
• Using the rim of a margarita glass (about 3-4 inches across), make circle imprints into rolled dough.
• Using a paring knife, make sure circles are cut all the way through.
• Roll each circle of dough around a metal cannoli tube, overlaping the ends and press to seal, flaring out the edges slightly.
• Fry one or two at a time in hot melted shortening (about 360°F) for approximately 1 minute, turning to brown all sides.
• Remove from hot grease and drain on paper towels, seam side down.
• Let cool a minute or two before trying to remove metal tube.
• To remove the tube hold cannoli shell down on the paper towel and carefully slide the tube out one end.
• Leave cannoil shells on paper towel, seam side down to cool completely.
• ~NOTE~Shells can be stored in airtight containers and made several days prior to filling.
• For filling, drain ricotta cheese over cheesecloth if ricotta is watery.
• Combine ricotta cheese, powdered sugar, and vanilla extract until combined.
• Squeeze Maraschino cherries with paper towels to remove all liquid.
• (If you don't squeeze them good, you will have a pink water filling!).
• Stir in cherries and chocolate chips into the ricotta mixture, being careful not to over mix.
• For a lighter filling, you may whip 1 cup of heavy whipping cream to form stiff peaks, and fold into filling mixture at this step.
• Chill filling for about 30 minutes before piping into cooled cannoli shells.
• You may garnish the cannoli by sprinkling powdered sugar on top.
• Whipped cream, a cherry, and shaved chocolate can also be used to garnish the top.
• Keep refrigerated until time of serving.

Steps:

• Three or more days in advance of making the cannoli shells set the ricotta in a colander inside of a large bowl.
• Scrape the ricotta into the colander and cover with plastic wrap.
• Let the ricotta drain in the refrigerator for two days, until it is dry.
• To make the dough for cannoli shells: In a small bowl put eggs.
• Beat eggs; add vanilla and ice water to eggs.
• In a large bowl, use your hands to combine the flour, sugar, salt, cocoa, and cinnamon.
• Add the shortening and mix until crumbly.
• Make well in dry mixture and add wet mixture.
• Using your hands mix together, if it is dry, add more ice water.
• Turn the dough out onto a lightly floured surface and knead until smooth and well blended, about 3 minutes.
• Shape the dough into a flattened ball.
• Cover with plastic wrap and let rest at room temperature for at least 30 to 60 minutes.
• Cut the dough into 4 pieces.
• Starting at the middle setting, run one of the pieces of dough through the rollers of a pasta machine or the dough can be rolled on a board with a rolling pin.
• Lightly dust the dough with flour as needed to keep the pieces from sticking.
• Continue to pass the dough through the machine until you reach the last or second to last setting.
• You might need to run the dough through the pasta machine three times.
• The dough needs to be thin-about the same thickness as construction paper; cut the dough into 4 1/2 inch circles. (Giovanna's cannoli tubes are 6 inches long and 1 inch in diameter.).
• Continue rolling out the remaining dough.
• If you do not have enough cannoli tubes for all of the dough, lay the pieces of dough on sheets of plastic wrap and keep them covered until you are ready to use them.
• Put a rack in the bottom of a large heavy kettle that you plan on putting your peanut oil into so that your cannoli shells do not touch the bottom and burn. (Giovanna uses a restaurant kettle that is about 18 inches in diameter.).
• Pour about 2 inches of oil in a smaller kettle. Giovanna used 4 quarts but her kettle is huge!
• Heat oil until a deep frying thermometer shows 375 degrees.
• Oil the cannoli tubes by placing them in the hot oil then draining them in a metal bowl (you need the oil on the tube so that later the cannoli shell will slip off easily).
• Lay the dough circle flat, center the tube on it, bring left edge onto tube, dab it with egg white, bring up right side of dough circle, dab it with egg white, and roll the tube; do not press the dough. You do not want the dough to be too tight on the tube, or you will have difficulty later getting your cannoli off. Be careful not to stretch the dough or pull it tightly. Avoid, as best as possible, getting egg white on the tube, or the cannoli will stick to it.
• Repeat with the remaining dough.
• Carefully lower a few of the cannoli tubes into the hot oil. Do not crowd the pan.
• Fry the shells until golden, about 2 minutes, turning them so that they brown evenly.
• With tongs, remove the cannoli tubes, holding them straight up so that the oil flows back into the pan.
• Then drain the cannoli still on tube briefly in a metal bowl.
• While the cannoli shells are still hot, carefully slide the shells off the tubes by grasping each tube with a clean towel and gently twisting the cannoli shell off the tube with your other hand protected by an oven mitt or towel. On another work surface area, lay oilcloth or newspaper, topped with a large rack.
• When the cannoli shells are barely warm set them on top of the rack.
• It is important that the shells stay on the racks overnight.
• Repeat with the remaining dough.
• If you are reusing the cannoli tubes, let them cool before wrapping them in the dough; set aside.
• The cannoli shells can be made up to 2 months before serving if you drain them properly overnight, and store them in sealed containers in a cool, dry place, but not in a refrigerator.
• To make the ricotta cream, put the thoroughly dry ricotta in a large mixing bowl with a wire whip and blend until creamy.
• Add the confectioners' sugar, granulated sugar, vanilla, and cinnamon oil; blend until smooth.
• Transfer to a bowl and stir in the chocolate pieces. Store the ricotta cream in the refrigerator for 48 hours. After 48 hours, serve and freeze the rest.
• Frozen ricotta cream can be defrosted in the refrigerator later.
• To assemble, use a knife to push the ricotta cream into the cannoli shell.
• Place the cannoli on a serving platter and sprinkle with confectioners' sugar.
• Use within an hour.